2023 Toyota Tacoma Problems & Recalls
Comprehensive defect analysis based on official US Federal safety databases.
2023 Toyota Tacoma Top Failure Categories
Distribution of driver complaints across vehicle components according to federal taxonomy.
Official Safety Recalls for 2023 Toyota Tacoma (4)
Defect Summary: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2023 Tacoma vehicles. One or more of the individual welds in the upper child seat anchors may be insufficient. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 225, "Child Restraint Anchorage System."
Safety Hazard: An insufficient weld may prevent the child seat from being anchored properly, allowing the seat to move during a sudden stop or crash, increasing the risk of injury.
Free Remedy: Dealers will inspect the upper child seat anchors and reweld the child seat anchors, as necessary. Owner notification letters are expected to be mailed September 02, 2022. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 22TB09/ 22TA09.
Defect Summary: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023 Corolla, Corolla Cross, Corolla Cross Hybrid, Highlander, Highlander Hybrid, Tacoma, 2023 Lexus RX350, RX350 Hybrid, RX500 Hybrid, 2023-2024 Lexus NX250, NX350, and NX350 Hybrid vehicles. An electrical connection inside the steering column's spiral cable assembly may be insufficiently welded, causing the connection to separate and deactivate the driver's air bag. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Safety Hazard: A deactivated driver's air bag that does not deploy as intended increases the risk of injury during a crash.
Free Remedy: Dealers will inspect and replace the spiral cable assembly, if necessary, free of charge. Owner notification letters were mailed September 8, 2023. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 23TA08. Lexus' number for this recall is 23LA02.
Defect Summary: Toyota Motor Engineering & Manufacturer (Toyota) is recalling certain 2022-2023 Tacoma vehicles. The axle shaft sub-assembly may separate from the axle housing due to debris causing improperly secured fasteners.
Safety Hazard: Axle shaft separation can cause a loss of vehicle stability and brake performance, increasing the risk of a crash.
Free Remedy: Dealers will inspect the rear axle assembly, tighten the axle retaining nuts as necessary, and repair or replace any damaged components, free of charge. Owner notification letters were mailed April 17, 2024. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 24TB05 and 24TA05.
Defect Summary: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023 Toyota Corolla, Corolla Cross, Corolla Cross Hybrid, Highlander, Highlander Hybrid, Tacoma, Lexus RX350, 2023-2024 NX250, and NX350 vehicles that may have been incorrectly repaired under previous NHTSA recall number 23V-480. An electrical connection inside the steering column's spiral cable assembly may be insufficiently welded, causing the connection to separate and deactivate the driver's air bag. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Safety Hazard: A deactivated driver's air bag will not deploy as intended, increasing the risk of injury during a crash.
Free Remedy: Dealers will inspect and replace the spiral cable assembly as necessary, free of charge. Owner notification letters were mailed March 17, 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 25TA02. Lexus' number for this recall is 25LA02.
Verified NHTSA Owner Complaints
Excerpts of actual incident reports submitted to the federal Office of Defects Investigation (ODI).
"Check BSM light came on Dealer found chafed wiring harness"
"After initial start of engine and at idle there is surge of the engine and lunge forward while in drive. The danger is unexpected forward movement of the truck when pulling forward at idle by lunging forward with risk of hitting that which is directly in front such as a parked car or the front of my garage. This is an ongoing event."
"On XXX I was driving on [XXX] at about 70mph, when the rear drivers side window on a 2023 Toyota tacoma crew cab shattered suddenly. If someone had been sitting in the backseat when this occurred they could have been injured. The door panel itself was damaged from the tiny shards of glass. It was a dangerous situation as glass was most likely sh..."
"The contact owns a 2023 Toyota Tacoma. The contact stated that the transmission failed to operate properly while driving 35 MPH and attempting to accelerate. While driving uphill or downhill, the transmission was slow to shift into the intended gear, and the vehicle was slow to accelerate. Additionally, there was an abnormal sound while turning the..."
"The contact owns a 2023 Toyota Tacoma. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 24V152000 (POWER TRAIN). The contact stated that while driving 55 MPH, the steering wheel was firm, the brake pedal was firm, and the vehicle was violently vibrating. Several unknown warning lights were illuminated. The message “Pull..."