2018 Toyota RAV4 Problems & Recalls
Comprehensive defect analysis based on official US Federal safety databases.
2018 Toyota RAV4 Top Failure Categories
Distribution of driver complaints across vehicle components according to federal taxonomy.
Official Safety Recalls for 2018 Toyota RAV4 (3)
Defect Summary: Southeast Toyota Distributors, LLC (SET) is recalling certain 2017-2019 Toyota Camry, Corolla, Rav4, Sienna, and Yaris iA vehicles equipped with factory-installed floor mats. The load carrying capacity modification label may be incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Safety Hazard: An incorrect label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.
Free Remedy: SET will notify owners and provide a corrected label for placement over the inaccurate label, free of charge. The recall began August 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371. SET's number for this recall is SET19A.
Defect Summary: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2017-2018 Toyota 4Runner and Tundra, 2018 Toyota Highlander, RAV4 and Lexus GX460 and 2017 Toyota Sienna and Tacoma vehicles. These vehicles may have incorrect load carrying capacity modification labels. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Safety Hazard: An incorrect load information label can result in the operator overloading the vehicle and increasing the risk of a crash.
Free Remedy: Toyota will notify owners and provide them with corrected labels, free of charge. The recall began on January 23, 2018. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are H0Z for Toyota vehicles, and HLF for Lexus vehicles.
Defect Summary: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Safety Hazard: A battery short circuit increases the risk of a fire.
Free Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Verified NHTSA Owner Complaints
Excerpts of actual incident reports submitted to the federal Office of Defects Investigation (ODI).
"All warning lights came on and started flashing, steering wheel locked completely and total system failure. Car suddenly died and I had no control of it. Engine started smoking with black smoke. I got out of car and engine immediately caught fire starting at the bottom left driver side of engine and within a few minutes vehicle was completely en..."
"The contact owns a 2018 Toyota RAV4. The contact stated that while driving at various speeds and turning right or left, the vehicle lost power and failed to accelerate as needed while depressing the accelerator pedal. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure, but no assistance w..."
"Cooper tires 225/65R17. Purchased 4 tires in June. From installation the tires were bouncy. The garage said it was the struts, so I replaced the struts, but the problem persists. 2 weeks later I took the car back. They said there was nothing wrong with t he tire. They rebalanced them. But that did not fix the problem. I took the car to a different ..."
"Before o had taken my RAV4 into Toyota for the recall a AAA tech. had replaced the battery after jump starting it. There was nothing wrong with the sensors or anything else but after the battery was replaced all the electric sensors that are for lane change warnings and cruise control etc. stopped working. I took vehicle into Toyota of Santa Maria ..."
"The contact owns a 2018 Toyota Rav4. The contact stated that while in reverse(R), the rear-view camera was black and failed to operate as intended. The vehicle was taken to a dealer where it was diagnosed and determined that the camera was inoperable and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failu..."