2016 Toyota RAV4 Problems & Recalls
Comprehensive defect analysis based on official US Federal safety databases.
2016 Toyota RAV4 Top Failure Categories
Distribution of driver complaints across vehicle components according to federal taxonomy.
Official Safety Recalls for 2016 Toyota RAV4 (3)
Defect Summary: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2016 Toyota RAV4 vehicles manufactured October 30, 2015, to February 3, 2016, 2016 Lexus RX350 vehicles manufactured October 26, 2015, to February 8, 2016, and 2016 Lexus ES350 vehicles manufactured September 1, 2015, to February 29, 2016. These vehicles are equipped with an ABS actuator that may have a damaged O-ring which could result in improper brake fluid pressure control during ABS, Traction Control, or Stability Control activation. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control Systems."
Safety Hazard: Insufficient brake fluid pressure may cause a loss of vehicle control, increasing the risk of a crash.
Free Remedy: Toyota will notify owners, and dealers will inspect the brake actuator, replacing it as necessary, free of charge. The recall began on May 4, 2016, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0I, GLC.
Defect Summary: Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2016 Toyota Yaris, Rav4, Land Cruiser and 4Runner vehicles, and Scion FR-S, iM, and TC vehicles manufactured January 28, 2016, to March 14, 2016. The Load Carrying Capacity Modification Label may not reflect the correct added weight of the installed accessories. As a result, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims for Passenger Cars."
Safety Hazard: An incorrect label may result in the vehicle being overloaded, increasing the risk of a crash.
Free Remedy: SET will notify owners, and provide them a corrected label to be installed over the inaccurate label, free of charge. The recall began on June 3, 2016. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET16A.
Defect Summary: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Safety Hazard: A battery short circuit increases the risk of a fire.
Free Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Verified NHTSA Owner Complaints
Excerpts of actual incident reports submitted to the federal Office of Defects Investigation (ODI).
"Mechanic said he thought rear lower rearward; non-adjustable control arms, lateral arms were a recall. They were falling apart. I've been complaining about a clunky noise for a year or so. Thank you for your help [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)"
"I was driving 9/3 and my left blinker light came on solid. I was not using my blinker. Within a few seconds my check engine light came on and another light. Then within 2 minutes the front left engine/tire caught fire."
""The red master warning triangle and an 'SRS Airbag System Malfunction' message illuminated unexpectedly on the dashboard of my 2016 Toyota Rav4 XLE under normal driving conditions. I contacted a certified Toyota dealership, and they confirmed that this dashboard warning indicates the vehicle's airbag system is completely disabled, leaving the occ..."
"The repair shop I was able to pull into as I was experiencing the issue with my vehicle reported: "Battery is unstable and is arcing off of the positive terminal. Battery tray, battery hold down tie, and battery j hook hold down were missing upon arrival." The issue was fixed by a Brakes Plus location, given I was able to pull in there - it was aro..."
"Intermittent stalling in various conditions including idling, highway driving and city driving."