2019 Toyota Prius Problems & Recalls
Comprehensive defect analysis based on official US Federal safety databases.
2019 Toyota Prius Top Failure Categories
Distribution of driver complaints across vehicle components according to federal taxonomy.
Official Safety Recalls for 2019 Toyota Prius (3)
Defect Summary: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019 Prius vehicles. An electrical short circuit in the combination meter could occur, causing the speedometer, the odometer, and the fuel gauge to go blank. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Controls and Displays."
Safety Hazard: A blank main display will not show important information like vehicle speed or fuel level. Driving with an inoperative display can increase the risk of a crash.
Free Remedy: Toyota will notify owners, and dealers will inspect the flash memory chip (ROM) production date, and if necessary, replace it along with the combination meter circuit board, free of charge. The recall began February 7, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's numbers for this recall are 19TA21 and 19TB21.
Defect Summary: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019 Lexus LS500, LC500, ES300h, UX250h, LS500h, Toyota Prius, RAV4 HV, 2019-2020 Toyota Prius Prime, and 2020 Corolla HV vehicles. The brake booster pump may fail causing a deactivation of the Vehicle Stability Control system and a loss of braking assist. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control Systems."
Safety Hazard: Deactivation of the vehicle stability control system or a loss of braking assist increases the risk of a crash.
Free Remedy: Toyota will notify owners, and dealers will inspect and, if necessary, replace the brake booster pump, free of charge. The recall began September 20, 2019. Toyota owners may contact Toyota customer service at 1-888-270-9371 and Lexus owners may contact Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are K1L/K0L. Lexus' numbers for this recall are K2F/KLF.
Defect Summary: Gulf States Toyota (GST) is recalling certain 2019 C-HR, 4Runner, Avalon, Avalon Hybrid, Camry, Camry Hybrid, Highlander, Land Cruiser, Prius, RAV4, Sequoia, Tacoma, Sienna, Tundra and Yaris vehicles. The text on the load capacity label may become illegible. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Safety Hazard: If the driver cannot read the label, they may unknowingly overload the vehicle, increasing the risk of a crash.
Free Remedy: GST will notify owners, and dealers will provide corrected load carrying capacity modification labels, free of charge. The recall began May 24, 2019. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 19R1.
Verified NHTSA Owner Complaints
Excerpts of actual incident reports submitted to the federal Office of Defects Investigation (ODI).
"Coolant is leaking into the catalytic converter. This seems to be a common issue. Toyota issued a technical service bulletin on XXX covering this exactly. Some 2016–2019 Prius and 2017–2019 Prius Prime vehicles may exhibit low coolant level, MIL on with DTC P148F00, and/or poor heater performance due to coolant leakage at the front exhaust pipe..."
"Frequency when I start car makes a very loud , painful high pitch noise for anywhere from 5-15 seconds"
"Body of car has rust perforation starting from the inside working out. This is on the roof, so water incursion will effect airbags and electrical system. FIrst noticed rust bubbles a few years ago, but did not think much of it. Now two body shops have said roof panel needs to be replaced. This is big stuff!"
"Since October 2023, my 2019 Toyota Prius has developed severe and unpredictable driving behavior after a regular brake service, which may have triggered or coincided with a software or ECU update. The car, which had been driving smoothly since I bought it in 2021, suddenly began showing false braking, steering interference, and lane instability — a..."