2023 Toyota 4Runner Problems & Recalls
Comprehensive defect analysis based on official US Federal safety databases.
2023 Toyota 4Runner Top Failure Categories
Distribution of driver complaints across vehicle components according to federal taxonomy.
Official Safety Recalls for 2023 Toyota 4Runner (1)
Defect Summary: Southeast Toyota Distributors, LLC (SET) is recalling certain 2023 Toyota 4Runner vehicles. The load carrying capacity modification label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Safety Hazard: An overloaded vehicle increases the risk of a crash.
Free Remedy: Southeast Toyota Distributors, LLC will mail a new modified label, free of charge. Owner notification letters were mailed December 1, 2023. Owners may contact SET's customer service at 1-866-405-4226. SET's number for this recall is SET23A.
Verified NHTSA Owner Complaints
Excerpts of actual incident reports submitted to the federal Office of Defects Investigation (ODI).
"Vehicle Component: Solid Rear Axle Assembly / Rear Suspension GeometryDefect Summary: The vehicle exhibits a factory manufacturing defect causing severe rear axle misalignment. At approximately 350 miles from new, an official dealership Hunter alignment report documented out-of-spec rear alignment parameters (-0.16° rear total toe) on a non-adjusta..."
"The contact owns a 2023 Toyota 4Runner. The contact stated that the driver's side door failed to lock using the key fob or the buttons on the door. The doors had to be manually locked and unlocked. The vehicle was taken to the dealer, where it was confirmed to be a known issue, and the locks were replaced. Shortly after the vehicle was repaired, th..."
"Purchased size 265/70R17 tires (Michelin Defender LTX M/S2) exhibiting severe highway vibration immediately post-installation. The vibration persisted continuously for two years across every rotation, posing serious handling and steering risks. For two years, local shop staff gaslit the customer, claiming an "out-of-round" tire or casing defect wa..."
"New, strange noise started in Dec'25 (41K miles; 2yrs 9 months). No warning lights. Diagnosed as failed brake accumulator (first at an independent shop, later at the dealer). Apparently the accumulator is part of the full master cylinder assembly which must be replaced. Toyota has quoted $3,200 to complete this repair and is telling me it must ..."
"I was driving the vehicle and suddenly the steering wheel started to getting hard to turn it and the dash board doesn’t show any failure I went right away to dealership close by they inspected the vehicle they states there is a power steering failure but the car never showed any failure on dashboard or safety system"