2016 Kia Sportage Problems & Recalls
Comprehensive defect analysis based on official US Federal safety databases.
2016 Kia Sportage Top Failure Categories
Distribution of driver complaints across vehicle components according to federal taxonomy.
Official Safety Recalls for 2016 Kia Sportage (2)
Defect Summary: Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
Safety Hazard: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Free Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Defect Summary: Kia Motors America (Kia) is recalling certain 2016-2018 K900 and 2014-2016 Sportage vehicles. The Hydraulic Electronic Control Unit (HECU) module could malfunction and cause an electrical short, which could result in an engine compartment fire.
Safety Hazard: An engine compartment fire while parked or driving can increase the risk of injury.
Free Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a new fuse for the HECU circuit board, free of charge. Owner notification letters were mailed September 22, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC227.
Verified NHTSA Owner Complaints
Excerpts of actual incident reports submitted to the federal Office of Defects Investigation (ODI).
"My 2016 Kia Sportage LX experienced a catastrophic engine seizure on September 9, 2026, at 91,249 miles. My son was returning home on I-95 South in Florida. After exiting at Sample Road and traveling west near Seabra Foods at approximately 40 mph, he first noticed unusual engine noises at an estimated 91,245 miles. He pulled over, immediately call..."
"The Hydraulic Electronic Control Unit (HECU) and electrical system malfunctioned, causing a severe short circuit, total power collapse, and an engine compartment thermal event (heavy smoke). The vehicle has an open, incomplete federal safety recall (NHTSA 22V051 / Kia SC227) for this exact fire and short-circuit hazard. The vehicle is intact, unmod..."
"I have a 2016 Kia Sportage Ex with under 71k miles. I’ve reach out the Kia headquarters about my engine in July because my engine has a blow by. My vehicle has never been in an accident and I always keep my engine clean. I always change my oil on time and now I’m having engine failure with under 71k miles??!! I’ve only done local driving and now Ki..."
"The vehicle suffered a sudden, catastrophic mechanical engine failure while driving. The vehicle completely lost acceleration, entered a low-pitched humming 'limp-home mode,' and the dashboard red oil pressure warning light illuminated solidly.The vehicle had previously received the mandatory corporate KSDS software update. A diagnostic check by an..."
"The knock censor went out, once it was replaced and the oil changed it’s still knocking and unable to drive. Mechanic from out of state looked at it and now said he thinks there’s a problem with in the engine. The car is sitting in a driveway, 4 hours from a Kia dealership."