2020 Hyundai Tucson Problems & Recalls
Comprehensive defect analysis based on official US Federal safety databases.
2020 Hyundai Tucson Top Failure Categories
Distribution of driver complaints across vehicle components according to federal taxonomy.
Official Safety Recalls for 2020 Hyundai Tucson (1)
Defect Summary: Hyundai Motor America (Hyundai) recalled certain 2019-2021 Tucson vehicles on September 4, 2020. On December 30, 2020, Hyundai expanded the recall population, and added certain 2016-2018 Tucson vehicles. The Anti-lock Brake Hydraulic Electronic Control Unit (HECU) could corrode internally and cause an electrical short, possibly resulting in an engine compartment fire.
Safety Hazard: An engine compartment fire can increase the risk of injury or crash.
Free Remedy: Hyundai will notify owners, and dealers will replace the HECU fuse. For 2019-2021 model years, the Electronic Stability Control (ESC) software will also be updated. Recall repairs will be performed free of charge. Owners are advised to park outside and away from structures as a precaution until the recall repair is complete. The recall began November 2, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 195.
Verified NHTSA Owner Complaints
Excerpts of actual incident reports submitted to the federal Office of Defects Investigation (ODI).
"The contact owns a 2020 Hyundai Tucson. The contact stated that upon starting the vehicle, the check engine, master general, and forward collision warning lights were illuminated. The vehicle was taken to the dealer, where it was diagnosed, and the contact was advised that the multifunction camera had failed and needed to be replaced. The manufactu..."
"On XXX, while driving at freeway speed in [XXX] with my [XXX] son in the back seat, the engine of my 2020 Hyundai Tucson (2.4L Theta II GDI, approx. 99,108 miles) seized suddenly and without warning. I lost all motive power in moving traffic and coasted to the shoulder, where my son and I sat stranded for 30 minutes with smoke and a burning smell c..."
"Engine has defect that causes oil to heat at an unusual levels there for damaging other vehicle components such as The exhaust system parts clogging up and Triggering check engine warning lights for emissions."
"The contact owns a 2020 Hyundai Tucson. The contact stated that while the vehicle was receiving a routine oil change, the contact was informed that the oil pan was empty. The contact was advised to take the vehicle to the dealer. The contact was informed about a possible oil consumption test. The contact was informed that there was carbon blowing o..."
"Dealer completed update 9C2 Theta 2 emissions update. After update, the car sputters slightly and increased noise is heard from the tailpipe. Customer returned to dealer after driving the car in different temps and noted the above complaint. Dealer verified the complaint but continues to take no responsibility for the fault on the repair receipt by..."