2022 Hyundai Sonata Problems & Recalls
Comprehensive defect analysis based on official US Federal safety databases.
2022 Hyundai Sonata Top Failure Categories
Distribution of driver complaints across vehicle components according to federal taxonomy.
Official Safety Recalls for 2022 Hyundai Sonata (3)
Defect Summary: Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe and Sonata vehicles equipped with 2.5L turbocharged engines. Fuel may leak at the pipe connection between the high-pressure fuel pump and fuel rail.
Safety Hazard: A fuel leak increases the risk of a fire.
Free Remedy: Dealers will inspect and tighten, or replace the fuel pipe as necessary, free of charge. Owner notification letters were mailed on September 3, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 207.
Defect Summary: Hyundai Motor Company (Hyundai) is recalling certain 2021-2022 Santa Fe, Sonata, Veloster N, 2022 Santa Cruz, Elantra N, and Kona N vehicles. The vehicle's "fail-safe" limited-mobility drive mode may be impaired, when prompted by a transmission oil pump malfunction, which can result in a complete loss of drive power.
Safety Hazard: Loss of drive power increases the risk of a crash.
Free Remedy: Dealers will inspect and replace the transmission, as necessary. Dealers will also update the transmission control unit software. All repairs will be performed free of charge. Owner notification letters were mailed January 10, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 236.
Defect Summary: Hyundai Motor America (Hyundai) is recalling certain 2020-2023 Sonata vehicles. A damaged check valve can allow air to enter the fuel tank, causing it to expand and contact hot exhaust components, melting the tank.
Safety Hazard: A melted fuel tank can leak, increasing the risk of a fire.
Free Remedy: Dealers will inspect and replace the check valve. The fuel tank assembly will be inspected for damage and replaced if necessary. Additionally, dealers will inspect and update the engine control unit software. All repairs will be performed as necessary, free of charge. Owner notification letters were mailed beginning March 13, 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 286. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on November 19, 2025.
Verified NHTSA Owner Complaints
Excerpts of actual incident reports submitted to the federal Office of Defects Investigation (ODI).
"The fuel tank assembly became pressurized with compressed air due top worn purge control system check valve. This caused the tank to deform and the deformation of the tank led to the fuel pump being pushed out and the back seat of the car was completely unattached and no longer secured. There was a strong presence of gas smell in the car as well. T..."
"The passenger compartment climate control blower motor circuit suffered a severe thermal overload. The terminal overheated, shorted out, and physically melted the primary engine wiring harness (Part #91400-L0051) inside the main fuse block connector housing while the vehicle was operating. This caused an immediate smoke/fire hazard in the cabin and..."
"Fuse for A/C was blown, caught on fire, and melted components."
"The contact owns a 2022 Hyundai Sonata. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 25V796000 (Fuel System, Gasoline); however, while driving 70 MPH and depressing the accelerator pedal, the vehicle decelerated unintendedly. The check engine warning light illuminated. The contact stated that upon depressing the bra..."
"RECALL REMEDY FAILURE AND MANUFACTURER COERCION My Certified Pre-Owned 2022 Hyundai Sonata Limited has been held completely out of service at an authorized Hyundai facility since June 2, 2026, due to severe fuel tank expansion under active NHTSA Safety Recall 25V-796 (Hyundai Campaign 286).The dealership confirmed that the defective expanding plas..."