2020 Hyundai Santa Fe Problems & Recalls
Comprehensive defect analysis based on official US Federal safety databases.
2020 Hyundai Santa Fe Top Failure Categories
Distribution of driver complaints across vehicle components according to federal taxonomy.
Official Safety Recalls for 2020 Hyundai Santa Fe (2)
Defect Summary: Hyundai Motor America (Hyundai) is recalling certain 2020-2021 Santa Fe, 2021 Sonata, and Elantra vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash.
Safety Hazard: A windshield that detaches from a vehicle during a crash can increase the risk of injury.
Free Remedy: Dealers will remove and reinstall the front windshield panel, free of charge. Owner notification letters were mailed June 20, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 216.
Defect Summary: Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
Safety Hazard: A fire while parked or driving can increase the risk of injury.
Free Remedy: Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will install a new fuse and wire extension kit as necessary, free of charge. Owner notification letters were mailed starting May 16, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 244. This recall is an expansion of previous recall number 22V-633.
Verified NHTSA Owner Complaints
Excerpts of actual incident reports submitted to the federal Office of Defects Investigation (ODI).
"Hyundai Dealership, Pedder Hyundai of Poway, applied recall 9C2 to 2020 Santa Fe on 10/20/2026. Vehicle idle is now rough at startup and gas pedal angle no longer is reliable for controlling vehicle speed. Engine surges and jerks during initial operation on residential street due to software change. The vehicle did not operate in this manner for t..."
"My incident relates to peeling paint on my white 2020 Hyundai Santa Fe. The paint has started to bubble, crack and peel off on the rear hatch of the vehicle. Hyundai has had issues with white color paint peeling off on a variety of their vehicles, across multiple years. Hyundai issued an extended warranty program (Z05) to cover the issue. I took..."
"The vehicle is experience severe, progressive engine oil consumption, completely depleting its engine oil below the safe operating limit ("Low" mark on the dipstick) every 500 miles. This creates an imminent risk of sudden engine seizure, catastrophic mechanical failure, and sudden stalling at highway speeds. The authorized dealers (Safford Hyund..."
"THERE IS A RECALL FOR THE SAME ISSUE ON THIS MODEL … I HAVE A CLAIM INTO HYUNDAI TO ALLOW MY VEHICLE TO BE REPAIRED UNDER THE SAME RECALL. This is a very dangerously problem and wish it to be investigated for the 2.0 Turbo as well. X Hyundai issued two main fuel-related recalls for the 2021 Santa Fe equipped with 2.5-liter turbocharged engines due..."
"I do not know what caused this. Here is what happened. While parking the car suddenly accelerated, over the curb, on the sidewalk narrowly missing the building because I turned hard right to avoid the building and I was able to brake to a stop glancing off a concrete pillar. We could have been hurt crashing into the wall/windows, anyone on the walk..."